Linear LTC3810-5 60V同步降压电源转换解决方案

Linear LTC3810-5 60V同步降压电源转换解决方案关键词：电源管理,DC/DC转换器,可关电源Linear公司的LTC3810-5 是60V电流模式同步开关稳压电源控制器,工作电压高达60V,集成了1欧姆栅极驱动器,不需要电流检测电阻,双N-MOSFET同步驱动,具有极快的瞬态响应,基准电压0.5% 0.8V,可编程输出电压跟踪/软起动,主要用在48V通信和基站电源,网络设备和服务器,汽车和工业控制系统.本文介绍了LTC3810-5主要特性,方框图, 高效高压降压转换器和多种应用电路, DC1168A - LTC3810EUH-5评估板技术指标,电路图.LTC3810-5: 60V Current Mode Synchronous Switching Regulator ControllerThe LTC3810-5 is a synchronous step-down switching regulator controller that can directly step-down voltages from up to 60V, making it ideal for telecom and automotive applications. The LTC3810-5 uses a constant on-time valley current control architecture to deliver very low duty cycles with accurate cycle-by-cycle current limit, without requiring a sense resistor.A precise internal reference provides 0.5% DC accuracy. A high bandwidth (25MHz) error amplifier provides very fast line and load transient response. Large 1 gate drivers allow the LTC3810-5 to drive multiple MOSFETs for higher current applications. The operating frequency is selected by an external resistor and is compensated for variations in VIN and can also be synchronized to an external clock for switching-noise sensitive applications. A shutdown pin allows the LTC3810-5 to be turned off, reducing the supply current to 240A.Integrated bias control generates gate drive power from the input supply during start-up or when an output shortcircuit occurs, with the addition of a small external SOT23 MOSFET. When in regulation, power is derived from the output for higher efficiency.LTC3810-5主要特性:High Voltage Operation: Up to 60VLarge 1 Gate DriversNo Current Sense Resistor RequiredDual N-Channel MOSFET Synchronous DriveExtremely Fast Transient Response0.5% 0.8V Voltage ReferenceProgrammable Output Voltage Tracking/Soft-StartGenerates 5.5V Driver Supply from Input SupplySynchronizable to External ClockSelectable Pulse Skip Mode OperationPower Good Output Voltage MonitorAdjustable On-Time/Frequency: tON(MIN) 100nsAdjustable Cycle-by-Cycle Current LimitProgrammable Undervoltage LockoutOutput Overvoltage Protection5mmx 5mm QFN PackageLTC3810-5应用:48V Telecom and Base Station Power SuppliesNetworking Equipment, ServersAutomotive and Industrial Control Systems图1.LTC3810-5方框图图2.LTC3810-5高效高压降压转换器图3.LTC3810-5输入12-60V输出5V/6A 250kHz同步转换器图4.LTC3810-5输入7-60V输出5V/5A转换器图5.LTC3810-5输入15-60V输出3.3V/6A转换器DC1168A - LTC3810EUH-5评估板DC1168A - LTC3810EUH-5 Evaluation Kit Demonstration circuit 1168 is a current mode ynchronous switching regulator featuring the LTC3810-5. The circuit is configured as a synchronous step-down regulator operating at 250kHz switching frequency. Output voltage is 12V at 10A maximum load. The input voltage range is 14V 60V.The operating mode can be selected with jumper JP1. Depending on the position of this jumper, at low load the circuit will operate in forced continuous mode (for best load transient response at low current) or in pulse skip mode (for best efficiency at low current).A Power Good output is provided. The PGOOD output is normally high, with a pull up resistor to VLOGIC. If the output voltage is not within 10% of nominal value the PGOOD signal will go low.The switching frequency can be synchronized to an external clock signal.DC1168A - LTC3810EUH-5评估板技术指标:AO-Electronics 傲壹电子 官网： 中文网：图6.DC1168A - LTC3810EUH-5评估板电路图