Y系列10kV高压三相异步电动机介绍

编号：时间：2021年x月x日书山有路勤为径，学海无涯苦作舟页码：第12页 共12页西安电机厂产品Y系列(IP44)交流电机 发布时间： 2005-7-21 被阅览数： 4357 次 一、概述 Y系列电动机是一般用途的全封闭自扇冷式鼠笼型三相异步电动机。安装尺寸和功率等级符合IEC标准，外壳防护等级为IP44，冷却方法为IC411，连续工作制（S1）。适用于驱动无特殊要求的机械设备，如机床、泵、风机、压缩机、搅拌机、运输机械、农业机械、食品机械等。 Y系列电动机效率高、节能、堵转转矩高、噪音低、振动小、运行安全可靠。Y80315电动机符合Y系列（IP44）三相异步电动机技术条件JB/T9616-1999。Y355电动机符合Y系列（IP44）三相异步电动机技术条件JB5274-91。Y80315电动机采用B级绝缘。Y355电动机采用F级绝缘。额定电压为380V，额定频率为50Hz。功率3kW及以下为Y接法；其它功率均为接法。电动机运行地点的海拔不超过1000m；环境空气温度随季节变化，但不超过40；最低环境空气温度为-15；最湿月月平均最高相对湿度为90%；同时该月月平均最低温度不高于25。 电动机有一个轴伸，按用户需要，可制成双轴伸，第二轴伸亦能传递额定功率，但只能用联轴器传动。 按用户需要，还可供应其他功率、电压、频率、湿热带型（TH）、防护等级等电动机。 二、订货须知 1.订货时请注明电动机型号、功率、调速、电压、频率、噪声及安装型式等。若未注明噪声等级，均按2级供货。 2.对于5.5kW及以上的2极电动机和37kW及以上的4极电动机不能用皮带传动。 3.如有特殊要求，请在合同中注明，并事先与制造厂联系。型 号额定功率 额定电流 转速 效率 功率因数 堵转转矩堵转电流最大转矩噪声振动速度 重量额定转矩额定电流额定转矩1级2级kWAr/min%COS倍倍倍dB(A)mm/skg同步转速 3000r/min 2 级Y80M1-20.751.8283075.00.842.26.52.366711.817Y80M2-21.12.5283077.00.862.27.02.366711.818Y90S-21.53.4284078.00.852.27.02.370751.822Y90L-22.24.8284080.50.862.27.02.370751.825Y100L-236.4288082.00.872.27.02.374791.834Y112M-248.2289085.50.872.27.02.374791.845Y132S1-25.511.1290085.50.882.07.02.378831.867Y132S2-27.515290086.20.882.07.02.378831.872Y160M1-21121.8293087.20.882.07.02.382872.8115Y160M2-21529.4293088.20.882.07.02.382872.8125Y160L-218.535.5293089.00.892.07.02.282872.8145Y180M-22242.2294089.00.892.07.02.287922.8173Y200L1-23056.9295090.00.892.07.02.290952.8232Y200L2-23769.8295090.50.892.07.02.290952.8250Y225M-24584297091.50.892.07.02.290972.8312Y250M-255103297091.50.892.07.02.292974.5387Y280S-275139297092.00.892.07.02.294994.5515Y280M-290166297092.50.892.07.02.294994.5566Y315S-2110203298092.50.891.86.82.2991044.5922Y315M-2132242298093.00.891.86.82.2991044.51010Y315L1-2160292298093.50.891.86.82.2991044.51085Y315L2-2200365298093.50.891.86.82.2991044.51220Y355M1-2220399298094.20.891.26.92.21094.51710Y355M2-2250447298594.50.901.27.02.21114.51750Y355L1-2280499298594.70.901.27.12.21114.51900Y355L2-2315560298595.00.901.27.12.21114.52105同步转速 1500r/min 4 级Y80M1-40.551.5139073.00.762.46.02.356671.817Y80M2-40.752139074.50.762.36.02.356671.817Y90S-41.12.7140078.00.782.36.52.361671.825Y90L-41.53.7140079.00.792.36.52.362671.826Y100L1-42.25143081.00.822.27.02.365701.834Y100L2-436.8143082.50.812.27.02.365701.835Y112M-448.8144084.50.822.27.02.368741.847Y132S-45.511.6144085.50.842.27.02.370781.868Y132M-47.515.4144087.00.852.27.02.371781.879Y160M-41122.6146088.00.842.27.02.375821.8122Y160L-41530.3146088.50.852.27.02.377821.8142Y180M-418.535.9147091.00.862.07.02.277821.8174Y180L-42242.5147091.50.862.07.02.277821.8192Y200L-43056.8147092.20.872.07.02.279841.8253Y225S-43770.4148091.80.871.97.02.279841.8294Y225M-44584.2148092.30.881.97.02.279841.8327Y250M-455103148092.60.882.07.02.281862.8381Y280S-475140148092.70.881.97.02.285902.8535Y280M-490164148093.50.891.97.02.285902.8634Y315S-4110201148093.50.891.86.82.293982.8912Y315M-4132240148094.00.891.86.82.2961012.81048Y315L1-4160289148094.50.891.86.82.2961012.81105Y315L2-4200361148094.50.891.86.82.2961012.81260Y355M1-4220407148894.40.871.46.82.21064.51690Y355M3-4250461148894.70.871.46.82.21084.51800Y355L2-4280515148894.90.871.46.82.21084.51945Y355L3-4315578148895.20.871.46.92.21084.51985同步转速 1000r/min 6 级Y90S-60.752.391072.50.72.05.52.256651.821Y90L-61.13.291073.50.72.05.52.256651.824Y100L-61.5494077.50.72.06.02.262671.835Y112M-62.25.694080.50.72.06.02.262671.845Y132S-637.296083.00.82.06.52.266711.866Y132M1-649.496084.00.82.06.52.266711.875Y132M2-65.512.696085.30.82.06.52.266711.885Y160M-67.51797086.00.82.06.52.069751.8116Y160L-61124.697087.00.82.06.52.070751.8139Y180M-61531.497089.50.81.86.52.070781.8182Y200L1-618.537.797089.80.81.86.52.073781.8228Y200L2-62244.698090.20.81.86.52.073781.8246Y225M-63059.598090.20.91.76.52.076811.8294Y250M-6377298090.80.91.86.52.076812.8395Y280S-64585.498092.00.91.86.52.079842.8505Y280M-65510498092.00.91.86.52.079842.856Y315S-67514198092.80.91.66.52.087922.8850Y315M-69016998093.20.91.66.52.087922.8965Y315L1-611020698093.50.91.66.52.087922.81028Y315L2-613224698093.80.91.66.52.087922.81195Y355M1-616030099094.10.91.36.72.01024.51590Y355M2-618534799094.30.91.36.72.01024.51665Y355M4-620037599094.30.91.36.72.01024.51725Y355L1-622041199194.50.91.36.72.01024.51780Y355L3-625046699194.70.91.36.72.01054.51865同步转速 750r/min 8 级Y132S-82.25.871080.50.72.05.52.061661.866Y132M-837.771082.00.72.05.52.061661.876Y160M1-849.972084.00.72.06.02.064691.8105Y160M2-85.513.372085.00.72.06.02.064691.8115Y160L-87.517.772086.00.82.05.52.067691.8140Y180L-81124.873087.50.81.76.02.067721.8180Y200L-81534.173088.00.81.86.02.070721.8228Y225S-818.541.373089.50.81.76.02.070751.8265Y225M-82247.673090.00.81.86.02.070751.8296Y250M-8306373090.50.81.86.02.073751.8391Y280S-83778.274091.00.81.86.02.073782.8500Y280M-84593.274091.70.81.86.02.073782.8562Y315S-85511474092.00.81.66.52.082872.8875Y315M-87515274092.50.81.66.52.082872.81008Y315L1-89017974093.00.81.66.52.082872.81065Y315L2-811021874093.30.81.66.32.082872.81195Y355M2-813226474093.80.81.36.32.0994.51675Y355M4-816031974094.00.81.36.32.0994.51730Y355L3-818536874294.20.81.36.32.0994.51840Y355L4-820039874394.30.81.36.32.0994.51905同步转速 600r/min 10级Y315S-104510159091.50.71.46.02.082872.8838Y315M-105512359092.00.71.46.02.082872.8960Y315L2-107516459092.50.81.46.02.082872.81180Y355M1-109019159593.00.81.26.02.0964.51620Y355M2-1011023059593.20.81.26.02.0964.51775Y355L1-1013227559593.50.81.26.02.0964.51880Y/YR系列高压三相异步电动机 发布时间： 2005-7-19 被阅览数： 2749 次 Y系列6kV高压三相异步电动机一、概述 Y系列6kV高压三相异步电动机为笼型转子异步电动机。该电动机的防护等级为IP23，冷却方法为IC01。 本系列电动机具有高效、节能、噪声低、振动小、重量轻、性能可靠、安装维修方便等优点。 本系列电动机可作驱动各种不同机械之用。如通风机、压缩机、水泵、破碎机、切削机床及其它设备，并可供煤矿、机械工业、发电厂及各种工矿企业作原动机之用。 本系列电动机结构及安装型式为IMB3，定额是以连续工作制（S1）为基准的连续定额，电动机的额定频率为50Hz，额定电压为6kV，其它电压等级或特殊要求，在订货时可与用户共同商订。二、型号含义 Y 3551 4：“Y”表示笼型转子异步电动机；“3551”表示机座中心高355mm，1号铁心长；“4”表示极数。三、订货须知（用户订货时须注明如下要求） 电机型号(Y3551-4)、额定功率(220kW)、额定电压(6000V)、额定频率(50Hz)、同步转速(1500r/min)、安装方式(1MB3)、防护等级(1P23)、冷却方法(IC01)、绝缘等级(F级)、环境条件(海拔1000m，环境温度40)。注：2、4极电机禁止用皮带轮传动；其它极数若用户需要用皮带轮传动，事先应与制造厂协商。型 号额定 功率额定 电流转速效率功率因数最大转矩起动转矩起动电流J(电机)J(负载)重量额定转矩额定转矩额定电流kWAr/min%COS倍倍倍kgm2kgm2kgY7101-43150361.8 149096.3 0.87 1.80.56.511554010500Y7102-43550407.7 96.3 12960011000Y7103-44000458.9 96.4 14860011500Y7104-44500516.3 96.4 16560012000Y8001-45000566.6 96.5 0.88 24060013000Y8002-45600634.6 96.5 26073013800Y8003-46300713.1 96.6 29079014500Y7101-62240261.1 99096.0 0.86 1.8 0.6 6.5 175195010500Y7102-62500291.1 96.1 190200011000Y7103-62800326.0 96.1 210255011500Y7104-63150366.4 96.2 235295012000Y8001-63550412.0 96.2 320305013000Y8002-64000464.3 96.3 385340013600Y8003-64500522.3 96.3 385340014000Y8004-65000580.3 96.4 440355015000Y7101-81800213.6 74096.4 0.85 1.8 0.6 6.5 230310011000Y7102-82000237.1 95.5 260320011500Y7103-82240265.3 95.6 270320012000Y8001-82500295.7 95.7 500510013000Y8002-82800330.9 95.8 590540014000Y8003-83150372.2 95.8 590540014500Y8004-83550419.1 95.9 710540015500型 号额定 功率额定 电流转速效率功率因数起动电流起动转矩最大转矩GD2重量加油周期额定电流额定转矩额定转矩kWAr/min%COS倍倍倍kgm2kghY3551-222026.7 297592.8 0.86 7.0 0.6 1.8 17805000Y3552-225030.1 92.9 1790Y3553-228033.7 93.1 1800Y3554-231537.7 93.4 1895Y3555-235542.4 93.7 1955Y3556-240047.6 94.1 2065Y4001-245053.3 297594.4 182300Y4002-250058.5 94.6 0.87 202400Y4003-256065.4 94.7 212500Y4004-263073.4 298094.9 232600Y4501-271082.7 297595.0 3550Y4502-280092.9 95.2 3680Y4503-2900104.5 95.3 3850Y4504-21000114.6 95.4 0.88 4100Y5001-21120128.2 298095.5 4250Y5002-21250143.0 95.6 4400Y5003-21400159.9 95.7 4600Y5004-21600182.6 95.8 4800Y5601-21800205.2 298095.9 0.88 6250Y5602-22000227.8 96.0 6550Y5603-22240254.9 96.1 6950Y6301-22500281.0 298096.2 0.89 7600Y6302-22800314.4 96.3 7900Y6303-23150353.7 96.3 8300Y3551-422026.3 148093.3 0.85 6.5 0.8 1.8 1417108000Y3552-425029.6 93.4 151760Y3553-428033.0 93.5 0.86 161800Y3554-431537.1 93.6 171860Y4003-435541.5 148593.8 262280Y4004-440046.4 94.0 292350Y4005-445052.1 94.2 312420Y4006-450057.6 94.3 0.87 0.8 332510Y4007-456064.5 94.5 362600Y4505-463072.2 148594.8 5030926000Y4506-471081.6 95.0 533180Y4507-480091.6 95.1 5833004000Y4509-4900102.6 95.2 683520Y5006-41000113.7 149095.3 0.87 0.7 1104010Y5007-41120126.7 95.4 0.88 1204160Y5009-41250139.9 95.5 14044702000Y50010-41400157.2 95.6 1504620Y5601-41600180.8 148595.7 0.89 0.6 6400Y5602-41800203.2 95.8 6700Y5603-42000225.5 95.9 7000Y6301-42240252.3 148596.0 0.89 0.6 7600Y6302-42500281.3 96.1 7900Y6303-42800314.7 96.2 8300Y3555-622027.3 98593.0 0.82 6.0 0.8 1.8 3118708000Y3556-625030.8 93.3 331930Y4004-628033.8 98593.5 0.83 0.8 4623106000Y4005-631537.8 93.7 502380Y4006-635542.5 93.9 532460Y4007-640047.7 94.0 582550Y4505-645052.8 99094.3 0.84 0.8 7130508000Y4506-650058.7 94.5 0.85 773140Y4507-656065.7 94.7 843240Y4509-663073.3 94.8 983470Y5006-671081.6 99095.0 0.85 0.7 15739106000Y5007-680091.2 95.1 1714050Y5009-6900102.3 95.2 20043304000Y50010-61000113.6 95.3 2154480Y5601-61120131.4 99095.4 0.86 6.5 0.7 6300Y5602-61250146.5 95.5 6600Y5603-61400163.9 95.6 7000Y6301-61600187.1 99095.7 0.86 6.5 0.7 7600Y6302-61800210.2 95.8 7900Y6303-62000233.3 95.9 8300Y4005-820026.3 74092.8 0.78 5.5 0.8 1.8 5023608000Y4006-822028.7 92.9 532440Y4007-825032.2 93.0 0.79 582520Y4008-828035.8 93.2 632620Y4506-831539.8 74093.4 0.80 5.5 0.8 7731208000Y4507-835544.5 93.5 843230Y4508-840050.0 93.7 913350Y4509-845056.3 93.8 0.81 983460Y5005-850061.7 74094.3 0.81 5.5 0.8 14637908000Y5007-856068.1 94.4 0.82 1714030Y5008-863076.5 94.5 1864180Y50010-871086.1 94.6 2154460Y5601-880096.8 74094.7 0.84 6.0 0.7 6300Y5602-8900108.8 94.8 6500Y5603-81000120.7 94.9 6900Y6301-81120135.1 74095.0 0.84 6.0 0.7 7500Y6302-81250150.6 95.1 7800Y6303-81400168.5 95.2 8200Y6304-81600192.3 95.3 8500Y4504-1020026.2 59091.9 0.77 5.5 0.8 1.8 9528708000Y4505-1022028.6 92.1 1032940Y4506-1025032.3 92.3 0.78 1103030Y4507-1028035.9 92.5 1203120Y4508-1031540.3 92.6 0.79 1303230Y4509-1035545.5 92.8 1403310Y5005-1040049.4 59093.3 0.80 5.5 0.8 19037208000Y5006-1045055.5 93.4 2043830Y5007-1050061.5 93.6 2233960Y5008-1056069.0 93.7 2424090Y50010-1063077.0 93.8 2804320Y5601-1071088.6 59094.0 0.82 6.0 0.7 6300Y5602-1080099.7 94.2 6500Y5603-10900112.0 94.3 6800Y6301-101000124.3 59094.4 0.82 6.0 0.7 7400Y6302-101120138.9 94.6 7700Y6303-101250154.7 94.8 8100Y6304-101400173.1 94.9 8500Y4507-1220028.4 49591.2 0.72 5.5 0.8 1.8 12030908000Y4508-1222030.7 91.4 0.73 1303190Y4509-1225034.2 91.7 1403280Y5006-1228038.4 49592.7 0.74 5.5 0.8 20437608000Y5007-1231542.4 92.8 0.75 2233900Y5008-1235547.1 93.0 2424040Y5009-1240052.8 93.3 2604180Y50010-1245059.3 93.4 2804320Y5601-1250065.0 49593.7 0.79 6.0 0.7 6000Y5602-1256072.7 93.8 6200Y5603-1263081.7 93.9 6400Y6301-1271092.0 49594.0 0.79 6.0 0.7 7400Y6302-12800103.4 94.2 7700Y6303-12900116.3 94.3 8100Y6304-121000129.0 94.4 8500型 号额定功率额定电流转速效率功率因数最大转矩转子电压转子电流重量额定转矩kWAr/min%COS倍VAkgYR3551-422027.5 148092.7 0.83 1.82954731960YR3552-425030.8 93.0 0.84 3254862050YR3553-428034.5 93.1 3624902120YR4001-431538.3 93.2 0.85 4234552850YR4002-435543.1 93.3 4724692960YR4003-440048.5 93.5 5204773070YR4004-445054.4 93.7 5184813200YR4005-450060.3 93.9 5785343300YR4501-456067.3 94.2 5146843750YR4502-463074.6 94.5 0.86 5716923870YR4503-471084.0 94.6 6426944130YR4504-480093.6 94.7 0.87 7346844160YR5001-4900105.3 94.8 7567364700YR5002-41000116.6 94.9 8198154850YR5003-41120130.4 95.0 8949164950YR5004-41250145.4 95.1 98310225120YR5601-41400162.7 95.2 8988786900YR5602-41600185.7 95.3 13977007200YR5603-41800208.7 95.4 14707517500YR6301-42000231.6 95.5 15547898100YR6302-42240259.2 95.6 16428358400YR6303-42500289.0 95.7 17248658800YR4001-622028.3 98092.5 0.81 1.84373162820YR4002-625031.7 92.7 0.82 4683552920YR4003-628035.4 92.8 5053483050YR4004-631539.8 93.0 5473613150YR4005-635544.7 93.2 5973723250YR4501-640049.6 93.5 0.83 5504603700YR4502-645055.1 93.6 0.84 6004743820YR4503-650061.1 93.8 0.84 6604763940YR4504-656068.3 94.0 7334784060YR5001-663075.7 94.3 0.85 6606084650YR5002-671085.1 94.5 7326104820YR5003-680095.7 94.7 8256175120YR5004-6900107.5 94.8 9426085650YR5601-61000119.2 98595.0 9426606800YR5602-61120133.3 95.1 11356127100YR5603-61250148.6 95.2 12306307400YR6301-61400166.3 95.3 13436448100YR6302-61600189.9 95.4 14666558400YR6303-61800213.4 95.5 16106708800YR4003-822029.5 74092.2 0.78 1.84443113000YR4004-825033.4 92.3 4753303100YR4005-828036.9 92.5 0.79 5123433200YR4501-831540.9 92.6 0.80 5043983700YR4502-835546.1 92.7 5474133820YR4503-840051.8 93.0 5974273940YR4504-845057.5 93.2 0.81 6574364060YR5001-850063.6 93.5 5965334450YR5002-856071.0 93.7 6575424700YR5003-863079.7 93.9 7315485000YR5004-871089.8 94.0 8205465350YR5601-8800100.9 94.2 8205906700YR5602-8900113.4 94.3 10115407000YR5603-81000125.8 94.4 10845777400YR6301-81120140.8 94.5 11696008000YR6302-81250157.0 94.6 12606108300YR6303-81400175.6 94.7 13406308700YR6304-81600200.5 94.8 14206609000YR4501-1022030.1 59091.3 0.77 1.84763013550YR4502-1225034.2 91.5 5003233680YR4503-1028037.7 91.8 0.78 5543343800YR4504-1031542.3 91.8 5943443920YR4505-1035547.6 92.1 6533534020YR5001-1040053.2 92.8 5934354720YR5002-1045059.7 93.1 5534444920YR5003-1050065.3 93.3 0.79 7254415120YR5004-1056073.0 93.5 8164375320YR5601-1063081.0 93.6 0.80 8244836500YR5602-1071091.1 93.7 8715116700YR5603-10800102.6 93.8 9305307000YR6301-10900115.3 93.9 10105407900YR6302-101000127.8 94.1 10925768200YR6303-101120143.0 94.2 11605858600YR6304-101250159.4 94.3 12306159000YR4504-1222032.6 49590.4 0.72 1.85042823900YR4505-1225036.6 91.5 5472984000YR5001-1228040.3 91.7 0.73 4304244720YR5002-1231544.6 92.0 0.74 4904154900YR5003-1235549.5 92.1 0.75 5294345100YR5004-1240055.6 92.3 5724535300YR5601-1245060.8 92.5 0.77 730