施工升降机安全管理手册.doc

档案号_安徽水安建设集团股份有限公司建筑施工升降机安全管理手册（试行）工程监督注册号 设备注册备案号 工程名称 建设单位 监理单位 安装单位 拆卸单位 定期检查单位 施工单位 安拆日期 安徽水安建设集团股份有限公司安技部制使用说明 根据建设工程安全生产管理条例、特种设备安全监察条例、建筑起重机械安全监督管理规定等要求，编制本手册。本手册一式二份，档案号由安徽水安建设集团公司安技部统一编制。由设备使用、安拆、维保和监理等单位如实填写并安排专人负责保管。 我公司建筑施工现场使用的每台建筑起重机械都应建立本手册，做到一机一册，并与以下资料并组成现场设备管理档案资料： 1、设备制造许可证或生产许可证 2、产品合格证 3、起重机械制造监督检验证书 4、产品使用说明书 5、安徽水安建筑起重机械注册备案卡 6、安拆方案（含安装、加节、附墙、拆除和周边环境防护）7、安拆、使用管理登记表8、按拆单位资质证书和安全生产许可证9、安拆人员特种作业操作证1 0、操作人员特种作业操作证1l、安全技术交底（安拆和使用）12、安拆合同13、检测报告（整机和安全防坠器）14、交接班记录15、其它有关资料概 况设备名称设备型号产品合格证号生产厂家出厂日期安全防坠器最A笼：近检测时间B笼：设备注册备案号监督检验证号附墙数量自由端允许高度 M最大安装高度 M附墙间距M额载人员 人额定载荷标准节规格长M宽M高M产权单位负责人联系电话目 录序号表格名称页码备注1安徽水安建筑施工升降机进场验收表 1页2安徽水安建筑施工升降机基础验收表 2页3安徽水安建筑施工升降机首次安装验收表 3-4页4安徽水安建筑施工升降机加节安装验收表 5-12页5安徽水安建筑施工升降机定期检查记录表 13-36页6安徽水安建筑施工升降机特种作业操作人员变更登记表 37页7 页8 页9 页10 页1 1 页12 页13 页14 页1 5 页16 页17 页安徽水安建筑施工升降机进场验收表验收项目验收内容验收情况产权单位使用单位监理单位安全保护装置是否齐全、无损坏吊笼门机械锁止装置和电气联锁装置围栏门电气和机械联锁装置安全防坠器吊笼防坠安全钩防松绳保险装置上下限位、极限开关和JE挡装置吊笼、对重等缓冲装置电气控制系统主要结构件腐蚀磨损状况是否符合标准要求立管壁厚最大减少量不超过原厚度的25%卷筒、滑轮、钢丝绳、齿轮齿条、吊钩、连接件 （销轴、螺栓）等易损构件是否符合标准要求 设备安全 技术档案 是否齐全特种设备制造许可证（03年以后出厂的设备）或生产许可证（03年以前出厂的设备）产品合格证起重机械制造监督检验证明书（07年3月份以后的设备）产品使用说明书安徽水安建筑起重机械注册备案卡安全防坠器有效标定期限不超过一年的检测报告验收结论产权单位使用单位监理单位 签字：（章）日期： 签字：（章）日期： 签字：（章）日期：注意：加号验收内容是保证项目，必须符合要求。安徽水安建筑施工升降机基础验收表验收项目验收内容验收情况使用单位监理单位 地基 及 基础地基与基础（含桩基）隐蔽验收记录（钢筋、预埋件和尺寸等）基础混凝土强度符合要求（附试验报告）预埋件符合要求避雷、接地线等是否按要求设置基面平整，排水通畅 周边 环境周边存在外电影响的安全隐患时防护措施是否到位。（附方 寨）基础周边有涵、基坑等时，防护措施方案是否齐全有效（附方案）基础设置在地下室顶板上，已取得设计部门出具相应的认可资料并按要求进行加固处理（附相关资料） 验收 结论使用单位监理单位 签字： （章）日期： 签字： （章）日期：安徽水安建筑施工升降机首次安装验收表本次安装后总高度_M验收项目验 收 内 容验收情况安装单位产权单位使用单位监理单位量化验收试验记录吊笼在上限位处动作时距顶端的安全距离： m吊笼停在完全压缩的缓冲装置上对重距顶端的安全距离： m上限位开关与上极限开关的越程距离为： m导轨架轴心线对底座水平基准面垂直度南北偏差： mm，东西偏差： mm已安装高度 m；自由端实际高度： m导轨架（标准节）中心线距建筑物垂直距离： m结构机械部分基础制作是否与相关专项验收、专项方案相符基础排水措施是否有效、无积水主要连接件（螺栓、销、轴等）是否符合相关标准规范，齐全可靠主要受力钢结构件是否有严重的锈蚀磨损、塑性变形、和裂纹开焊附墙的安装制作是否符合产品说明书要求各传动装置是否无漏油、无振动、无异响、运行平稳，相应防护措施齐全可靠齿轮齿条啮合是否符合标准标准节齿条连接是否牢固相邻两标准节的齿条及导轨立管的阶差是否符合相关规范要各部位滑轮、导轮是否完好无严重磨损，符合相关标准规范要求各润滑部位是否润滑，油位是否正常，油质是否符合要求钢丝绳是否存在严重的断股断丝、扭曲变形等或已达报废标钢丝绳的连接固定、绳卡是否符合规范标准对重块搁置位置、轨道相关安全防护是否符合标准规范、安全可靠护栏、踢脚板、电缆挑线架等附属结构是否符合标准安全可靠验收项目验 收 内 容验收情况安装单位产权单位使用单位监理单位电气部分电气保护装置（相序、过欠压、过流过载、继电器等）是否齐全有效用电是否采用TN-S接零保护系统用电是否采用L一机一闸一漏一箱各部分电器、电线电缆等：相关参数设置是否符合相关标准规范要求是否符合相关安全使用标准且无隐患，安全可靠安装固定是否可靠绝缘电阻值是否大于0.5M Q吊笼内是否有照明且有效接零接地保护是否符合相关规范标准接零接地保护电阻值是否小于4Q安全保险装置上、下限位开关和极限开关及止挡装置是否符合规范要求，且灵敏可靠安全防坠器有效标定日期是否未超过1年吊笼防坠安全钩是否齐全可靠防松绳保险装置是否齐全可靠围栏门、吊笼门等机械、电气的联锁保险装置是否灵敏可靠吊笼、对重的缓冲装置是否齐全有效底部进料口防护棚搭设且符合安全标准料台层门接料平台搭设和层门制作安装是否符合相关规范文件要求，安全可靠接料平台登机边缘与吊笼门框外缘水平距离是否小于50mm各楼层是否设置与吊笼内相联系的呼叫信号装置相关方案相关安装（含附墙）方案是否编制并且审批其它安装（含附墙）单位资质、安装（含附墙）分包合同、安装操作人员交底持证情况、操作人员交接班运转记录、定期检查记录等是否合格、真实、有效（查专项验收资料）是否取得特种设备法定检测机构出具的检测合格报告验收结论 安装单位 产权单位 使用单位 监理单位 签字： （章）日期 签字： （章）日期 签字：（章）日期签字：（章）日期安徽水安建筑施工升降机第 次加节安装（从 节到 节）验收表本次安装后总高度_M验收项目 验 收 内 容 验收情况安装单位产权单位使用单位监理单位量化验收试验记录吊笼在上限位处动作时距顶端的安全距离： m上限位开关与上极限开关，J越程距离为： m导轨架轴心线对底座水平基准面垂直度南北偏差： mm，东西偏差： mm白由端实际高度： m导轨架（标准节）中心线距建筑物垂直距离： m结构机械部分主要连接件（螺栓、销、轴等）是否符合相关标准规范，齐全可靠主要受力钢结构件是否有严重的锈蚀磨损、塑性变形和裂纹开焊，标准节轨道锈蚀磨损量是否小于原设计值的25%（新安装部分）附墙的安装制作是否符合产品说明斗望呈奎求各传动装置是否无漏油、振动、异响、运行平稳，防护措施齐全可靠齿轮齿条啮合是否符合标准、标准节齿条连接是否牢固相邻两标准节的齿条及导轨立管的阶差是否符合相关规范要求各部位滑轮、导轮是否完好无严重磨损，符合相关标准规范要求各润滑部位是否润滑，油位是否正常，油质是否符合要求钢幺幺绳是否存在严重的断股断丝、扭曲变形等或已达报废标准铡丝绳的连接固定、绳卡是否符合规范标准对晕块搁置位置、轨道相关安全防护是否符合标准规范、安全可靠护栏、踢脚板、电缆挑线架等附属结构是否符合标准安全可靠防松绳保险装置是否齐全可靠围栏门、吊笼门等机械、电气的联锁保险装置是否灵敏可靠料台层门接料平台搭设和层门制作安装是否符合相关规范文件要求，安全可靠接料平台登机边缘与吊笼门框外缘水平距离是否小于50mm各楼层是否设置与吊笼内相联系的呼叫信号装置相关方案资料相关加节安装（含附墙）方案是否编制并且审批加节安装（含附墙）单位资质、加节安装（含附墙）分包合同、安装操作人员交底持证情况、操作人员交接班运转记录、定期检查记录等是否合格、真实、有效（查专项验收资料）验收结论 安装单位 产权单位 使用单位 监理单位 签字： （章）日期 签字： （章）日期 签字： （章）日期 签字： （章）日期安徽水安建筑施工升降机定期检查记录表定期检查项目定期检查内容检查单位意见使用单位意见主要机械结构部分基础承载构件、标准节、附墙、吊笼等主要受力承载结构件是否存在锈蚀磨损严重、变形、脱焊或存在锈蚀磨损量超标，达报废更换标准护栏、爬梯、踢脚板、各种平台走台、驾驶室等安全防护设施是否存在与相关标准规范、设备使用说明书不符或存在锈蚀磨损严重、脱焊、构件缺失、不牢不稳等安全隐患基础、标准节、天轮、附墙撑拉杆等结构件固定拼装用的螺栓、销、轴等连接件的安装制作、磨损锈蚀是否存在违反相关标准规范和使用说明二饽要求的安全隐患导轨架轴心线对底座水平基准面的安装垂直度偏差是否符合标准规范要求是否存在其它安全隐患传动机构电动机、减速机构、连轴器、制动装置及滑轮导轮、齿轮齿条等各部位的拼装连接固定是否稳固、安全可靠，符合相关标准规范各传动部位需润滑的滑轮导轮、齿轮齿条、轴承及钢丝绳等是否缺少润滑各滑轮导轮、齿轮齿条、轴承等是否存在断裂、缺失、磨损过大或间隙超标与相关标准规范、设计使用说明书要求不符各电机、制动装置等需防护部位的防护措施是否到位、有效减速机等需注油结构件是否漏油、油位是否正常、油质是否合格传动机构整体运行是否平稳、无异响，安全可靠是否存在其它安全隐患电气部分整体配电是否符合rN-S要求，各电气件参数设置是否合格各部位的电线电缆以及电器开关、变阻器、配电柜等电气件安装、固定、防护是否到位符合设计使用说明书要求安全可靠各接线桩头、触点是否符合相关标准规范要求安全可靠各操作手柄、开关、按钮和指示灯照明是否灵敏可靠符合安全使用标准和设计使用说明书要求各电气安装配备和安全保护装置是否存在损坏、缺失、弃用或未按照相关标准规范要求设置电气各部位的电阻值、绝缘值等测量数据是否符合相应的要求是否存在其它安全隐患限位保险安全防坠器是否符合相关规范标准要求灵敏可靠安全安全防坠器每三个月坠落试验结果符合要求A笼 制动距离 M B笼 制动距离 M 围栏登机门机械、电气联锁装置是否符合要求灵敏安全可靠 各吊笼门的电气联锁和机械锁止装置、上下限位和上下极限限位及止档装置等是否符合相应的标准规范要求灵敏可靠蛊令 吊笼安全钩是否符合相关标准规范和设计使用说明书要求安全可靠 吊笼内是否设置超载装置且符合相关标准规范和设计使用说明寸5要求灵敏安全可靠 吊笼和对重底部缓冲装置是否安全可靠 是否存在其它安全隐患 定期检查单位 使用单位 监理单位检查发现存在主要问题：签字：（章）使用单位整改情况：签字：（章）监理单位监督意见： 签字： （章）说明：施工升降机首次定期检查应在使用后半个月内开展，以后每半个月一次定 i 期开展。安徽水安建筑施工升降机特种作业操作人员变更登记表工种姓名特种作业操作证号身份证号使用单位签字监理单位签字司机变更栏工种姓名特种佾蚴耕锁E号身份证号使用单位签字监理单位签字司机g an employment tribunal claimEmployment tribunals sort out disagreements between employers and employees.You may need to make a claim to an employment tribunal if: you dont agree with the disciplinary action your employer has taken against you your employer dismisses you and you think that you have been dismissed unfairly.For more information about dismissal and unfair dismissal, seeDismissal.You can make a claim to an employment tribunal, even if you haventappealedagainst the disciplinary action your employer has taken against you. However, if you win your case, the tribunal may reduce any compensation awarded to you as a result of your failure to appeal.Remember that in most cases you must make an application to an employment tribunal within three months of the date when the event you are complaining about happened. If your application is received after this time limit, the tribunal will not usually accept it.If you are worried about how the time limits apply to you, take advice from one of the organisations listed underFurther help.Employment tribunals are less formal than some other courts, but it is still a legal process and you will need to give evidence under an oath or affirmation.Most people find making a claim to an employment tribunal challenging. If you are thinking about making a claim to an employment tribunal, you should get help straight away from one of the organisations listed underFurther help.If you are being represented by a solicitor at the tribunal, they may ask you to sign an agreement where you pay their fee out of your compensation if you win the case. This is known as adamages-based agreement. In England and Wales, your solicitor cant charge you more than 35% of your compensation if you win the case.If you are thinking about signing up for a damages-based agreement, you should make sure youre clear about the terms of the agreement. It might be best to get advice from an experienced adviser, for example, at a Citizens Advice Bureau. To find your nearest CAB, including those that give advice by e-mail, click onnearest CAB.For more information about making a claim to an employment tribunal, seeEmployment tribunals.The (lack of) air up there Watch mCayman Islands-based Webb, the head of Fifas anti-racism taskforce, is in London for the Football Associations 150th anniversary celebrations and will attend Citys Premier League match at Chelsea on Sunday.I am going to be at the match tomorrow and I have asked to meet Yaya Toure, he told BBC Sport.For me its about how he felt and I would like to speak to him first to find out what his experience was.Uefa hasopened disciplinary proceedings against CSKAfor the racist behaviour of their fans duringCitys 2-1 win.Michel Platini, president of European footballs governing body, has also ordered an immediate investigation into the referees actions.CSKA said they were surprised and disappointed by Toures complaint. In a statement the Russian side added: We found no racist insults from fans of CSKA.Age has reached the end of the beginning of a word. May be guilty in his seems to passing a lot of different life became the appearance of the same day; May be back in the past, to oneself the paranoid weird belief disillusionment, these days, my mind has been very messy, in my mind constantly. Always feel oneself should go to do something, or write something. Twenty years of life trajectory deeply shallow, suddenly feel something, do it.一字开头的年龄已经到了尾声。或许是愧疚于自己似乎把转瞬即逝的很多个不同的日子过成了同一天的样子；或许是追溯过去，对自己那些近乎偏执的怪异信念的醒悟，这些天以来，思绪一直很凌乱，在脑海中不断纠缠。总觉得自己自己似乎应该去做点什么，或者写点什么。二十年的人生轨迹深深浅浅，突然就感觉到有些事情，非做不可了。The end of our life, and can meet many things really do?而穷尽我们的一生，又能遇到多少事情是真正地非做不可？During my childhood, think lucky money and new clothes are necessary for New Year, but as the advance of the age, will be more and more found that those things are optional; Junior high school, thought to have a crush on just means that the real growth, but over the past three years later, his writing of alumni in peace, suddenly found that isnt really grow up, it seems is not so important; Then in high school, think dont want to give vent to out your inner voice can be in the high school children of the feelings in a period, but was eventually infarction when graduation party in the throat, later again stood on the pitch he has sweat profusely, looked at his thrown a basketball hoops, suddenly found himself has already cant remember his appearance.童年时，觉得压岁钱和新衣服是过年必备，但是随着年龄的推进，会越来越发现，那些东西根本就可有可无；初中时，以为要有一场暗恋才意味着真正的成长，但三年过去后，自己心平气和的写同学录的时候，突然就发现是不是真正的成长了，好像并没有那么重要了；然后到了高中，觉得非要吐露出自己的心声才能为高中生涯里的懵懂情愫划上一个句点，但毕业晚会的时候最终还是被梗塞在了咽喉，后来再次站在他曾经挥汗如雨的球场，看着他投过篮球的球框时，突然间发现自己已经想不起他的容颜。Originally, this world, can produce a chemical reaction to an event, in addition to resolutely, have to do, and time.原来，这个世界上，对某个事件能产生化学反应的，除了非做不可的坚决，还有，时间。A persons time, your ideas are always special to clear. Want, want, line is clear, as if nothing could shake his. Also once seemed to be determined to do something, but more often is he backed out at last. Dislike his cowardice, finally found that there are a lot of love, there are a lot of miss, like shadow really have been doomed. Those who do, just green years oneself give oneself an arm injection, or is a self-righteous spiritual.一个人的时候，自己的想法总是特别地清晰。想要的，不想要的，界限明确，好像没有什么可以撼动自己。也曾经好像已经下定了决心去做某件事，但更多的时候是最后又打起了退堂鼓。嫌恶过自己的怯懦，最终却发现有很多缘分，有很多错过，好像冥冥之中真的已经注定。那些曾经所谓的非做不可，只是青葱年华里自己给自己注射的一支强心剂，或者说，是自以为是的精神寄托罢了。At the moment, the sky is dark, the air is fresh factor after just rained. Suddenly thought of blue plaid shirt; Those were broken into various shapes of stationery; From the corner at the beginning of deep friendship; Have declared the end of the encounter that havent start planning. Those years, those days of do, finally, like youth, will end in our life.此刻，天空是阴暗的，空气里有着刚下过雨之后的清新因子。突然想到那件蓝格子衬衫；那些被折成各种各样形状的信纸；那段从街角深巷伊始的友谊；还有那场还没有开始就宣告了终结的邂逅计划那些年那些天的非做不可，终于和青春一样，都将在我们的人生中谢幕。Baumgartner the disappointing news: Mission aborted. r plays an important role in this mission. Starting at the ground, conditions have to be very calm - winds less than 2 mph, with no precipitation or humidity and limited cloud cover. The balloon, with capsule attached, will move through the lower level of the atmosphere (the troposphere) where our day-to-day weather lives. It will climb higher than the tip of Mount Everest (5.5 miles/8.85 kilometers), drifting even higher than the cruising altitude of commercial airliners (5.6 miles/9.17 kilometers) and into the stratosphere. As he crosses the boundary layer (called the tropopause),e can expect a lot of turbulence.The supersonic descent could happen as early as Sunda.The weatheThe balloon will slowly drift to the edge of space at 120,000 feet ( Then, I would assume, he will slowly step out onto something resembling an Olympic diving platform.Below, the Earth becomes the concrete bottom of a swimming pool that he wants to land on, but not too hard. Still, hell be traveling fast, so despite the distance, it will not be like diving into the deep end of a pool. It will be like he is diving into the shallow end. Skydiver preps for the big jumpWhen he jumps, he is expected to reach the speed of sound - 690 mph (1,110 kph) - in less than 40 seconds. Like hitting the top of the water, he will begin to slow as he approaches the more dense air closer to Earth. But this will not be enough to stop him completely.If he goes too fast or spins out of control, he has a stabilization parachute that can be deployed to slow him down. His team hopes its not needed. Instead, he plans to deploy his 270-square-foot (25-square-meter) main chute at an altitude of around 5,000 feet (1,524 meters).In order to deploy this chute successfully, he will have to slow to 172 mph (277 kph). He will have a reserve parachute that will open automatically if he loses consciousness at mach speeds.Even if everything goes as planned, it wont. Baumgartner still will free fall at a speed that would cause you and me to pass out, and no parachute is guaranteed to work higher than 25,000 feet (7,620 meters).cause there