MPW张紧绞车备件手册(PLC版)

MPW张紧绞车备件手册北京山潜天恒科技有限公司MPW张紧绞车备件手册说明1、零件件号以 MPWEXXX , MPW M XXX , MPWC XXX , MPW HXXX , MPWGXXX为标准格式进行编制。其中：E代表电器零部件，M代表机械零部件，C代表水冷系统零部件，H代表液压站 零部件，G代表减速机零部件2、手册中各图片均为示意图，仅供参考，最终以实际产品为准3、如由于产品技术改造或升级造成的产品外观和零部件数量的更改会在最新版本的手册中 进行更新4、 用户如需采购手册中零部件，请与北京山潜天恒科技有限公司销售人员联系联系电话：010-88203446传真：010-88202117Email:yhzhou mountain .c n1-# -序 号件号名称单台 数量备注1MPW-E-OO1绞车主电机12MPW-E-074 (A)主电机风扇1新版本电机3MPW-E-074 (B)主电机风扇1旧版本电机4MPW-M-OO1主电机底座15MPW-M-002主电机安装螺栓组8组紧固主电机和底座MPV-M-002PFV/E001MPV-E-074MR)序 号件号名称单台 数量备注1MPW-M-003电机侧联轴器12MPW-M-004减速机侧联轴器13MPW-M-005弹性联轴器销轴8配螺母、平垫、弹垫4MPW-M-006弹性体4X 8-3 -MPW-M-024MPW-M-010MPV-M-007MPW-M-O13/15/16MPV-M-O174MPV-M-023序 号件号名称单台 数量备注序 号件号名称单台 数量备注1MPW-M-007Brevini减速机+制 动器18MPW-M-016轴承座密封毡条1内部2MPW-M-O1O减速机侧支板19MPW-M-017轴承座盖紧固螺 栓4组3MPW-M-O11轴承侧支板110MPW-M-018轴承座紧固螺栓4组4MPW-M-012卷筒轴111MPW-M-023钢丝绳1卷图中示意5MPW-M-013轴承座112MPW-M-024U型螺栓3组6MPW-M-014轴承座盖17MPW-M-015轴承座盖密圭丁圈1内部5MPW-MQ09-MPW-M-021序 号件号名称单台 数量备注1MPW-M-008减速机花键套12MPW-M-009MPW绞车卷筒13MPW-M-019卷筒轴承14MPW-M-020轴承紧定套1组5MPW-M-021卷筒轴锁紧组件1组6MPW-M-022花键套紧固螺栓12组紧固花键套和卷筒序 号件号名称单台 数量备注1MPW-M-025减速机紧固螺栓28组紧固减速机和支板2MPW-M-026张力计170MPW-M-032/044MPV-M-03K MPV-M-036、MPV-M-038-MPW-M-035#0#0厂 MPW-M-034序号件号名称数量备注序号件号名称数量备注1MPW-M-029主电控箱体19MPW-M-036圆柱销2铰接支架和 支架盖2MPW-M-030主电控箱大门110MPW-M-037开口销23MPW-M-031主电控箱小门111MPW-M-038紧固螺栓组1组紧固支架盖4MPW-M-032隔爆腔盖112MPW-M-042门体紧固螺栓38组紧固门体15MPW-M-033主电控箱底座113MPW-M-043箱体紧固螺栓4组紧固箱体:6MPW-M-034冷却系统支架114MPW-M-044隔爆腔螺栓14组紧固腔盖子7MPW-M-035冷却系统支架盖115MPW-E-055冷却系统支架与 底座联结螺栓48MPW-E-054主电控箱与底座联结螺栓4MPW-M-043MPW-M-042序 号件号名称单台 数量备注序 号件号名称单台 数量备注1MPW-E-002M50防爆接头2参考实际数目6MPW-E-007M25防爆堵头7参考实际数目2MPW-E-003M40防爆接头3参考实际数目7MPW-E-132M32防爆堵头2参考实际数目3MPW-E-004M40防爆堵头2参考实际数目4MPW-E-005M32防爆接头4参考实际数目5MPW-E-006M25防爆接头3参考实际数目MP04MPV/-E-002MPW-E-00MPVE-007-*10序 号件号名称单台 数量备注1MPW-E-029变频器12MPW-E-030模拟I/O扩展模块13MPW-E-031变频器通信模块14MPW-E-042变频器安装螺栓45MPW-E-032主电压器16MPW-E-034操作显示屏17MPW-E-035操作显示屏支架1配安装螺钉4组8MPW-E-044主电压器安装螺栓4组紧固主变压器MPW-C-002序 号件号名称单台 数量备注1MPW-C-001卧式水泵+底座12MPW-C-002水泵电机13MPW-C-003安装法兰24MPW-C-004安装法兰胶垫25MPW-C-005电机安装螺栓组4组:安装水泵电机和底座 :6MPW-C-006底座紧固螺栓组4组安装水泵底座和支架序 号件号名称单台 数量备注1MPW-C-007散热器12MPW-C-008散热器支架23MPW-C-009散热风扇+安装座1组4MPW-C-010风扇电机15MPW-C-011支架安装螺栓4组6MPW-C-012散热器安装螺栓4组7MPW-C-013风扇电机安装螺栓4组8MPW-C-014水管7-8m图中未作出9MPW-C-015水管卡子6图中未作出MPV-C-007MPV-C-009MPW-C-Ol?MPV-C-0111314MPW-E-023MPW-E-111MPW-E-036MPW-E-010MPW-E-014IPlT-E-020 MPW-E-028 MPW-E-017 MPW-E-019MPW-E-237A238/239/240MPW-E-109 -X尹 !*篡弃n-MPW-E-113y-MPW-E-011MPW-E-008-MPW-E015VPW-E-200A*3-二-二-f-三-=-MPW-E-088/089MPW-E-120MPW-E-022序 号件号名称单台 数量备注1MPW-E-008MPW主电控板12MPW-E-010辅助电机断路器23MPW-E-011变频器断路器14MPW-E-014辅助电机接触器25MPW-E-227母线排1连接两个断路器6MPW-E-013浪涌抑制器(压敏电 阻型)2位于接触器上7MPW-E-025辅助触头2位于断路器上8MPW-E-026接触器安装适配器2连接断路器和接触器9MPW-E-01524V(5A)直流电源110MPW-E-11324V(2A)DC 电源1序 号件号名称单台 数量备注11MPW-E-237本安型DI安全栅612MPW-E-238本安型DO驱动型安 全栅113MPW-E-239本安型电源型安全 栅114 :MPW-E-240本安型AI型安全栅:115MPW-E-036漏电线圈216MPW-E-111二路空开117 1MPW-E-200中间继电器318MPW-E-017漏电继电器219MPW-E-019PLC控制器120 :MPW-E-020PLC状态量输入模块1121MPW-E-028Modbus电缆122MPW-E-109线槽3m根据需要制作23MPW-E-110导轨:3m根据需要制作24 MPW-E-089端子UK5N RD1525MPW-E-088端子UK5N8626MPW-E-120隔离端子E/NS 35 N1227MPW-E-091端子挡片2228MPW-E-124短接片729MPW-E-022紧固螺钉3030MPW-E-023电控板紧固螺钉431MPW-E-136二极管1注：内部接线端子图中为示意序 号件号名称单台 数量备注1MPW-E-315主断路器12MPW-E-316主断路器支架1345678MPU-E-099oLMPW-E-093MPW-E-09SPV/-E-095肝 WE-088隔爆接线腔内部端子布置图序 号件号名称单台 数量备注1MPW-E-088端子UK5N162MPW-E-091挡片 D-UK 4/1063MPW-E-095接地端子USLKG 3514MPW-E-096端子UK 3535MPW-E-098接地端子USLKG 5016MPW-E-099端子UKH 5037MPW-E-120隔离端子E/NS 35 N68MPW-E-121隔离端子E/AL NS 35 N3铝质9MPW-E-124短接片2序 号件号名称单台 数量备注1MPW-E-057就地控制箱12MPW-E-058就地控制箱内部电控板13MPW-E-060weila nd 48路底开放底座14MPW-E-128weila nd 48芯外罩1未做出5MPW-E-062weila nd 24芯插座16MPW-E-262weila nd 24芯插针17MPW-E-047红色急停按钮18MPW-E-064三位选择开关19MPW-E-050指示灯110MPW-E-049黑色功能按钮111MPW-E-067黄色功能按钮212MPW-E-068大张力显示屏1显示屏以箱体尺 寸确定13MPW-E-268小张力显示屏114MPW-E-071尼龙电缆接头515MPW-E-073底座紧固螺钉4组16MPW-E-112门锁117MPW-E-127标牌2MPW-E-070就地控制箱内部面板端子序 号件号名称单台 数量备注1MPW-E-088接线端子UK 5N102MPW-E-091挡片 D-UK 4/1013MPW-E-120:隔离端子E/NS 35N24MPW-E-109线槽1m5MPW-E-110:导轨0.5m6MPW-E-072固定螺栓6紧固线槽、导轨注：此两零件在MPW-E-057 （就地控制箱）内部布置序 号件号名称单台 数量备注1MPW-E-069张力变送器12MPW-E-070张力变送器支架1PW-E-046/056序 号件号名称单台 数量备注1MPW-E-046本安操作箱12MPW-E-047急停按钮13MPW-E-048三位开关14MPW-E-049黑色功能开关15MPW-E-050工作指示灯16MPW-E-067黄色功能开关27MPW-E-128weila nd 48芯外罩1外部连接线用8MPW-E-062weila nd 24芯插座2未做出9MPW-E-262weila nd 24芯插针2外部连接线用10MPW-E-134weila nd 24芯外罩111MPW-E-12948芯电缆4m内部连接用12MPW-E-126标牌7块13MPW-E-06048路开放底座114MPW-E-05224路开放底座115MPW-E-056箱体紧固螺栓4组16MPW-E-071尼龙电缆接头417MPW-E-112门锁118MPW-E-130导轨固定螺栓3固定导轨19MPW-E-131外罩固定螺栓8固定外罩20MPW-E-A-1连接电缆总成1连接就地箱和本 安箱21注：PLC版 本安操作箱内部端子布置示意序 号件号名称单台 数量备注1MPW-E-088接线端子UK5N242MPW-E-091端子挡片D-UK 4/1023MPW-E-120隔离端子E/NS 35 N34MPW-E-110导轨0.5mMPW-H-004MPW-H-006MPW-H-003MPW-H-001MPW-H-002MPW-005MPW-H-011MPW-H-007序 号件号名称单台 数量备注1MPW-H-001油泵电机12MPW-H-002油箱13MPW-H-003呼吸器14MPW-H-004蓄能器15MPW-H-005电磁阀16MPW-H-006压力变送器17MPW-H-007液压阀块18MPW-H-008压力表1:图中未作出9MPW-H-009压力油管3m10MPW-H-010油管转接接头211MPW-H-011内部油泵1MPW-H-ASM-001液压站组件1包括以上全部MPV-H-010MPV-H-009ATX序 号件号名称单台 数量备注1MPW-G-001对接法兰12MPW-G-002轴承13MPW-G-003O型圈14MPW-G-004O型圈122序 号件号名称单台 数量备注1MPW-G-005内齿圈12MPW-G-006行星架13MPW-G-007太阳轮14MPW-G-008行星轮45MPW-G-009行星轮销轴46MPW-G-010隔离套47MPW-G-011轴承48MPW-G-012轴承19MPW-G-013卡圈810MPW-G-014卡圈411MPW-G-015端盖112MPW-G-016O型圈113MPW-G-017O型圈114MPW-G-018隔离套123序 号件号名称单台 数量备注1MPW-G-019外壳12MPW-G-020端盖13MPW-G-021轴承14MPW-G-022轴承15MPW-G-023油封26MPW-G-024磁性塞17MPW-G-025外壳紧固螺钉48MPW-G-026端盖紧固螺钉89MPW-G-027定位销110MPW-G-028O型圈111MPW-G-029O型圈112MPW-G-030卡圈110序 号件号名称单台 数量备注1MPW-G-031对接法兰12MPW-G-032轴承13MPW-G-033轴承14MPW-G-034定位销15MPW-G-035O型圈16MPW-G-036O型圈125序 号件号名称单台 数量备注序 号件号名称单台 数量备注1MPW-G-037对接法兰115MPW-G-051卡圈2MPW-G-038法兰117MPW-G-053双头螺栓84MPW-G-040齿轮轴118MPW-G-054螺钉67MPW-G-043轴承119MPW-G-055螺母88MPW-G-044摩擦片120MPW-G-056螺母69MPW-G-045制动器外壳121MPW-G-057垫圈813MPW-G-049O型圈122MPW-G-058垫圈614MPW-G-050O型圈MPW-G-ASM-001制动器组件1包括以上全部52801223251317 26序 号件号名称单台 数量备注序 号件号名称单台 数量备注1MPW-G-059外壳17MPW-G-065齿轮+齿圈12MPW-G-060法兰112MPW-G-066轴13MPW-G-061法兰113MPW-G-067垫片14MPW-G-062端盖114MPW-G-068垫片15MPW-G-063法兰115MPW-G-069垫片16MPW-G-064法兰116MPW-G-070轴承1序 号件号名称单台 数量备注序 号件号名称单台 数量备注17MPW-G-071轴承129MPW-G-082螺栓818MPW-G-072轴承130MPW-G-083螺钉1019MPW-G-073轴承133MPW-G-084平垫820MPW-G-074O型圈134MPW-G-085平垫1021MPW-G-075O型圈145MPW-G-086螺钉822MPW-G-076O型圈146MPW-G-087平垫823MPW-G-077O型圈147MPW-G-088盖125MPW-G-078键248MPW-G-089O型圈126MPW-G-079锁紧螺母149MPW-G-090螺钉427MPW-G-080制动垫片163MPW-G-091螺钉428MPW-G-081油封129注：以下为变频器备件参考资料件号名称备注MPW-E-113变频器冷却风扇01件号名称备注MPW-E-114变频器冷却风扇02件号名称备注MPW-E-115电路板安装支架件号名称备注MPW-E-116光纤电缆01件号名称备注MPW-E-117光纤电缆02件号名称备注MPW-E-118密封胶圈件号名称备注MPW-E-120水晶头（插件）件号名称备注MPW-E-121风扇外罩件号名称备注MPW-E-125衬垫件号名称备注MPW-E-127晶体管模块单元件号名称备注MPW-E-128铠装线缆件号名称备注MPW-E-129通道控制二极管安装板件号名称备注MPW-E-130滤波板件号名称备注MPW-E-131钳位电容ooooo件号名称备注MPW-E-132滤波器件号名称备注MPW-E-133滤波器电路板37件号名称备注MPW-E-135放电电阻件号名称备注MPW-E-138压敏电阻件号名称备注MPW-E-139充电电阻件号名称备注MPW-E-140操作面板件号名称备注MPW-E-142通讯模块40